Page 1 of 2

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
  
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
X
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
X
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   chlorine 200 ppm                   Dishwasher Temperature   chlorine 200 °F or label
Food Temperatures:   dressing 37, chicken soup 154, ham 39, beef 41, freezer 1, cheese 40, eggs 41, gravy 140, chili 156, steak -19
 
General Comments
No follow up is needed at this time. A huge improvement has been made in this facility thank you
HACCP: Make sure employees are washing hands in the hand sink not the 3 bay sink 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/17/2007 Time In  10:30 AM Time Out  12:20 PM Sanitation Score  90 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  90  
 
Page 2 of 2

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
5  Observed several refrigerators and freezers to not have thermometers *Please provide thermometers in all coolers and freezers (750.140) Next Inspection
8  Observed the ice scoop to be improperly stored *Provide for all utensils to be stored in one of the following manners: 1) Clean and dry 2) In the food product with the handle up and out of the food product (750.290) Next Inspection
15  Observed a torn gasket on the prep cooler *Please repair (750.690) Next Inspection
21  Observed wiping cloth(s) to be improperly stored: *Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used (750.810) Next Inspection
22  Observed the following food contact surfaces to be unclean: 1. spice containers 2. ladles and buckets put away dirty *Please clean (750.800) Next Inspection
23  Observed the following non-food contact surfaces to be unclean: 1. shelf with bread in prep area 2. gaskets on all coolers and freezers 3. inside friar cabinets 4. hanging shelves around hand sink 5. Outside spice containers 6. spice shelves 7. hand sink handles *Please clean (750.800) Next Inspection
37  Observed wall by hand sink to be in need of cleaning *Please clean (750.1220) Next Inspection
38  Observed the following lights to be unshielded: 1. Stand up freezer 2. Pie cooler *Please shield (750.1240) Next Inspection
     
     
     
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  12/17/2007 Time In  10:30 AM Time Out  12:20 PM Sanitation Score  90 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  90